Skoda Fabia

since 2000 release

Repair and operation of the car

Skoda Fabia
+ 1.1. Description of the car
+ 2. Engine
+ 3. Lubrication system
+ 4. Power supply system
+ 5. Cooling system
+ 6. System of production of the fulfilled gases
+ 7. Transmission and running gear
- 8. Steering
   8.1. Removal and installation of a steering wheel
   8.2. Removal and installation of returnable and contact rings assembled
   + 8.3. Steering column
   + 8.4. The steering mechanism (without amplifier)
   - 8.5. The steering mechanism (with the amplifier)
      8.5.1. Replacement of a tip of steering draft
      8.5.2. Removal of the steering mechanism
      8.5.3. Installation of the steering mechanism
      8.5.4. Replacement of steering draft
      8.5.5. Pump unit
      8.5.6. Check of electric chains of the amplifier of steering
      8.5.7. Replacement of the sensor of the amplifier of steering
      8.5.8. Replacement of highways of system of the amplifier of steering
      8.5.9. Check of level of working liquid
      8.5.10. Filling and removal of air from hydraulic system
      8.5.11. Check and adjustment of angles of installation of wheels
+ 9. Brake system
+ 10. Electric equipment
+ 11. Body
+ 12. Electrical circuitries

8.5.10. Filling and removal of air from hydraulic system

GENERAL INFORMATION

Prevention

You carry out gas station of hydraulic system of the amplifier of steering only at the cold engine.

Do not reuse liquid from system: it is polluted, saturated air and moisture.

Apply only those liquids which are recommended by manufacturer.

PERFORMANCE ORDER

1. Disconnect a wire from the - plug of the rechargeable battery. On a part of cars the holder of the rechargeable battery (the bigger size) closes a receiver cover. In this case it is necessary to remove the rechargeable battery and its holder (see subsection 10.2).

2. If necessary remove the air filter (see subsection 4.1).

3. Raise and establish a forward part of the car on reliable support.

4. Turn off a cover of a receiver and fill in in it working liquid to a tag And (see rice. A receiver cover with the index of level of liquid).

5. Connect a wire to the - plug of the rechargeable battery (if the battery is removed, connect it by means of auxiliary wires) and install the removed air filter.

6. Establish wheels in the situation corresponding to the rectilinear movement of the car and turn off a receiver cover.

7. Turn ten times a steering wheel from one extreme situation in another.

Prevention

It is forbidden to hold a steering wheel in extreme situation more than 10 pages.

8. Check liquid level in a receiver and if necessary add liquid to a mark A.

9. Slightly screw a receiver cover. Do not tighten it densely at all.

10. Launch the engine, let's it work 10 with and stop.

11. Check liquid level in a receiver and if necessary add liquid to a mark A.

12. Repeating three previous operations, achieve that liquid level in a receiver ceased to go down and stopped on a tag And.

13. Launch the engine, turn ten times a steering wheel from one extreme situation in another and stop the engine.

14. Check liquid level in a receiver and if necessary add liquid to A. Plotno's tag wrap a receiver cover.

15. Установитеь the rechargeable battery and the air filter if they were removed.